NEWS
Home > News > 10 Ton Coal Fired Chain Grate Boiler in Pakistan

10 Ton Coal Fired Chain Grate Boiler in Pakistan

Time:2015-08-28 13:49:33 Auther: Ailsa from ZG Boiler

 10-ton-coal-fired-chain-grate-boiler-in-Pakistan.jpg

10 ton chain grate coal fired boiler introduction
This series double drum boiler is horizontal moving chain grate coal fired boiler. The boiler has two drums and convection bank inside. Water wall tubes are placed in the burner at left and right side. There is a steam-water separator and surface blow down device fixed in the upper drum, and a periodic blow down device fixed in another drum which is at the bottom. The tail decorates economizer. Moving chain grate makes it convenient to feed coal, Induced draft fan and forced draft fan make good ventilation. Fuel from coal scuttle fall on grate stoker, enters the furnace was burned, the flame through the combustion chamber ,the economizer and was drew forth by induced draft fan and into the atmosphere.
Features of 10 ton coal fired chain grate boiler in Pakistan:
1. The boiler has two parts, the boiler body and the accessories which included coal scuttle, the chain grate stoker, base steel and the furnace wall. The boilers are assembled except midfeather when it leaves factory with economizer and duct furnace.
2. The fire grate of the boiler is light-weight moving chain grate. There are six independent air compartments under the fire grate and air registers placed at the both side of air compartment. Air can come into the air duct by the blower in the base, then into the independent wind room.
3. Upper furnace walls were assembled by the factory, the lower the furnace wall composed of clay brick and insulation material composition. The coal will pass by the coal gate to burn in the furnace from coal feeder. And the coal slag will be exhausted by the slag remover.
4. There is an electric control cabinet equipped with the boiler. The cabinet includes indicator of the Thermal Parameter, induced and forced draft fan, control buttons of the electric actuators, and over- temperature alarm device of the auto water feeder.
In Pakistan, their have a rich coal resource, so Pakistan company can use coal as fuel material to heating boilers. Besides, this 10 ton chain grate coal fired steam boiler also can using different biomass as fuels, like lees, wood chip, rice husks, palm shell etc.

Previous Page: Lignite Coal Fired Boiler for Sale
Next Page: 3 Ton Coal Fired Boiler for Sale in Pakistan
RELATED PRODUCTS
DZL Packaged Coal Fired Boiler
DZL Packaged Coal Fired Boiler
SZL Coal Fired Steam Boiler
SZL Coal Fired Steam Boiler
SZL Biomass Fired Boiler
SZL Biomass Fired Boiler
DZL Biomass Fired Boiler
DZL Biomass Fired Boiler
INQUIRY
If you have any suggestions or opinions about our products,please leave a message,and we will immediately answer your questions. thanks for your support.
Products you need:
Your name:
E-mail:
Phone Number:
Country or Region:
Message:
Please describe your requirements briefly.
TOP